How Is Water Getting In My Gas Tank?

Discussion in 'Gas Engines' started by Noob2U, Jul 9, 2009.

  1. Noob2U
    Joined: Jul 2009
    Posts: 5
    Likes: 0, Points: 0, Legacy Rep: 10
    Location: Michigan

    Noob2U Junior Member

    OK so I allow gas to pool around the fuel fill door then take a candle to it...right? check!

    (just kidding)

    We have a list of ideas to catch the culprits and determine tampering but, I'm finding it so hard to believe.

    This is what I know. Water Wins. The boat is about 8 years old and I'm afraid something has dried out/rotted/eroded over time and it's probably something that would cost more to get to than the boat is worth.
     
  2. FAST FRED
    Joined: Oct 2002
    Posts: 4,519
    Likes: 111, Points: 63, Legacy Rep: 1009
    Location: Conn in summers , Ortona FL in winter , with big d

    FAST FRED Senior Member

    If the tanks are below deck , folks from the BRONX would use crazy glue to install a few double edged razor blades in the area of the fuel cap.

    EZ to check at the local emergency room to see who came in with GUSHERS!

    FF
     
  3. mongo75
    Joined: Aug 2007
    Posts: 262
    Likes: 6, Points: 0, Legacy Rep: 95
    Location: Orange County California

    mongo75 Senior Member

    YES, a lit candle is safe around a gas cap. Jeez, as smart as most of you guys are I sometimes wonder- here's why. (1) the cap is sealed, so no vapors escape (2) gasoline vapors are heavier than air, so therefore they do not go up to the lit candle, but away from it. So before y'all go running around yelling the sky is falling, remeber your science class.
     
  4. apex1

    apex1 Guest

    To your (1): it is not! usually the cap has to act as a tank vent, through a labyrinth!

    to (2):
    read:
    A gas pool of course will ignite immediately.
    so far to the being smart comment.......................
     
  5. mark775

    mark775 Guest

    He's already done the most obvious - greasing new O-rings and installing caps tight. Maybe it's the bug/flame screen in the vents. Is the water in both tanks? Does the engine have a fuel cooler? That's a likely culprit if so...and they aren't even needed in temperate or cool climes.
     
  6. ancient kayaker
    Joined: Aug 2006
    Posts: 3,497
    Likes: 147, Points: 0, Legacy Rep: 2291
    Location: Alliston, Ontario, Canada

    ancient kayaker aka Terry Haines

    If vandalism is not the cause, with two mechanics not able to figure it out the real cause is an obscure one. Try to find out when it happens -this may enable the mech to diagnose the problem correctly next time.

    Water is either getting in during a trip or while it's sitting on the trailer, and it's either a background activity or a sudden event that can be linked to an external cause.

    If you can get a dip tube or other device that will detect water down to the bottom of the tank a regular intervals and before and after a trip, you may get the vital clue. At the least you should monitor the indicated level regularly and especially after rain for unexplained increases and to estabilish if it is gradual or sudden. The amounts of water you have experienced should show up clearly.
     
  7. FAST FRED
    Joined: Oct 2002
    Posts: 4,519
    Likes: 111, Points: 63, Legacy Rep: 1009
    Location: Conn in summers , Ortona FL in winter , with big d

    FAST FRED Senior Member

    Not all boats will vent with the tank cap, most with fixed tanks will have a vent line that goes overboard.

    Could this outside vent be installed upside down and work as a rain catcher?

    FF
     
  8. apex1

    apex1 Guest

    Well thats why I asked:
     
  9. mongo75
    Joined: Aug 2007
    Posts: 262
    Likes: 6, Points: 0, Legacy Rep: 95
    Location: Orange County California

    mongo75 Senior Member

    I don't know if gas caps are made different in Germany, but I have NEVER seen a cap in the US that has given me any kind of impression that it will not seal 100%- no vent what so ever. Hence every tank having an overboard drain.
     
  10. pistnbroke
    Joined: Jan 2009
    Posts: 1,405
    Likes: 34, Points: 48, Legacy Rep: 404
    Location: Noosa.Australia where god kissed the earth.

    pistnbroke I try

    water in tank easy ......stop pissing about ....
     
  11. apex1

    apex1 Guest

    You should look in boats, not helicopters! Others have seen that..........

     
  12. naturewaterboy
    Joined: Sep 2006
    Posts: 211
    Likes: 0, Points: 0, Legacy Rep: 10
    Location: key largo, florida, usa

    naturewaterboy Steel Drum Tuner

    My 2 cents worth is that your tank vent is letting water in if the water gets in while using the boat. But I'd check both the fuel fill hose and the vent hose, and check the tank. Another likely location is the fuel level sender assembly - it mounts in a big hole that is screwed onto the tank with a gasket. With the amount of water you are getting, sounds like maybe the gasket is bad or missing a screw, and the tank top holds water, funneling it into your tank.
     
  13. Luckless
    Joined: Mar 2009
    Posts: 158
    Likes: 7, Points: 18, Legacy Rep: 105
    Location: PEI, Canada

    Luckless Senior Member

    Rather than going back and forth on the issue of a candle flame near a gas tank, why not try an option that doesn't involve a candle? A small dab of caulking, or a tiny strip of red construction tape will do just as well.
     
    Last edited: Aug 1, 2009
  14. naturewaterboy
    Joined: Sep 2006
    Posts: 211
    Likes: 0, Points: 0, Legacy Rep: 10
    Location: key largo, florida, usa

    naturewaterboy Steel Drum Tuner

    What would a strip of tape do, and what is chalking? :confused: I like the suspense of candles near gasoline - you live life to the fullest when your close to death!:D
     

  15. powerabout
    Joined: Nov 2007
    Posts: 2,944
    Likes: 67, Points: 48, Legacy Rep: 719
    Location: Melbourne/Singapore/Italy

    powerabout Senior Member

    fill the tank right up to just below the filler cap and then wait to see what happens
     
Loading...
Forum posts represent the experience, opinion, and view of individual users. Boat Design Net does not necessarily endorse nor share the view of each individual post.
When making potentially dangerous or financial decisions, always employ and consult appropriate professionals. Your circumstances or experience may be different.